1．?進入潔凈室必須穿干凈的安全鞋并套上鞋套,戴安全帽。Clean safety shoes with shoe cover and helmet are required in the clean stage.(200 RMB)
2．?人員憑潔凈室胸卡從指定的隔離區進出，嚴禁從封閉門或其他地方進出。All person shall not enter or exit from closed door or other location except designated air lock room.(200 RMB)
3．?嚴禁使用他人工作證進入Forbid entering with other worker badge.(200 RMB confiscate both badges沒收兩人工作證)
4．?材料、器具經檢查許可后方可帶入,且材料、器具應保持清潔及無油污。Entrance control for materials, machines, tools shall be assured，these materials is clean and without oil stain.(200 RMB each item每件)
5．?帶入未經許可的工具或材料。Bringing unapproved tools and materials. .(500 RMB each item每件)
6．?物料進出必須走專用通道。Material entry or exit form special materials entrance.(500 RMB)
7．?高度潔凈階段，在潔凈室內需要戴專用的手套。Cleanroom gloves are required in the ultra clean stage area.(500 RMB)
8．?高度潔凈階段，進入潔凈室各區域都需按照標準穿戴潔凈好室防護用品。Clean working clothes are required in the ultra clean stage area.(500 RMB)
1．FAB區域要放置垃圾桶和收集箱供大家使用。Trash dumpsters or containers must be used in fab by all.
2．材料獨立包裝，材料進入潔凈室前必需在室外指定的區域除去外包裝，包裝箱要及時清走，丟入垃圾箱中。Materials for the interior of the building will arrive on site individually packed. Dirty materials shall be unpacked outside the building in a designated area. The outer box will be removed and disposed of into trash containers.(500-1000 RMB)
3．材料存放于指定區域并堆放整齊,做好標識。Orderly storage of material at designated area has to be assured during all stages of construction.(200 RMB)
4．潔凈室打掃衛生不可使用掃把，要用吸塵器打掃（日常清潔）。Vacuum cleaners have to be used to remove dust/rubbish; Brooms are not allowed(Daily housekeeping).(200 RMB)
5．工作中產生粉塵的作業，如鉆孔要及時用吸塵器清理。Vacuum cleaners have to be used to remove dust all time when carrying out dust working, such drilling.(200 RMB)
6.清潔作業必須采用HEPA過濾網吸塵器。HEPA filter vacuum cleaners have to be used to doing housekeeping.(500 RMB)
7．作業中產生的垃圾要及時收集.All trash must be collected at any moment during work.(200-400 RMB)
8．工作完畢要清理作業區域。Tidy your work area after work done.(200 RMB)
9．所有垃圾及報廢材料必需當天出現場. All trash and spent materials must be removed daily. .(200 RMB)
10.保持物品堆放整潔。Tidy your storage area.(200 RMB)
11.廠房內禁止吸煙No smoking allowed in clean room.(200 RMB)
12.禁止攜帶飲料和食品。No food or beverages allowed in clean room.(200 RMB)
13.禁止小便或吐痰。Forbid urinating or spitting. (1000-200 RMB confiscate badge沒收工作證)
1.潔凈室施工需提前提出施工申請,并不得過期使用。No work without permit or expired permit.(1000 RMB)
2．梯子尤其是作業平面需擦拭干凈才可進入潔凈室。Wipe down ladder before entering clean area, especially working platform. .(200 RMB each item每件)
3．作業平臺一旦弄臟，要立即清理出潔凈室。Dirty platform must be removed form cleanroom. (200 RMB each item每件)
4．未油漆過的管子需置于架空的板子上，不可放于地面。Unpainted sprinkle pipe on raise floor in cleanroom. .(200 RMB each item每件)
5．產生污染的作業（如鉆孔、打磨、切割等）必須申請，得到批準，做好防護措施后方可進行。Dirty work not allowed without approved isolation. .(200-400RMB)
6．作業中產生的污染物、碎片要用臨時搭設的墻面進行隔離。Temporary construction walls must be erected to isolate cleanroom from contamination generated during work. .(200-400 RMB)
7．在潔凈室內不能進行任何切割加工。Forbid to do any cutting in cleanroom.(500 RMB)
8．動火作業要搭設棚子進行隔離。Booth must erect for welding or hot work.(200 RMB)
9．氣瓶用塑料包裹，固定放置。Gas cylinder should wrap with plastic sheet. (200 RMB each item每件)
10．電線絕緣架空（至少2米）。Placing and isolating wires and cable on height. (At least2.0mheight)(200-400 RMB)
11．禁止堵塞通道，隨時保證通道的暢通、干凈整潔。Keep the corridor clean and clear; do not obstruct the corridor.（200 RMB）
12．非緊急情況禁止打開任何緊急進出門。Forbid opening any emergency door except emergency.(200 RMB)
13.預制氣割或焊接需在潔凈室外完成。Prefabrication shall complete outside of the cleanroom when using welding or cutting.(200 RMB)
1．可以承重的只有粗徑的凈化氣體和一般氣體不銹鋼管道和電線槽。Only Scrubbed/general exhaust ducting and electrical cable tray are sufficient strength for foothold.
2．禁止踩踏、攀附的管道有PVC管、塑膠管、危險化學品管道、細徑不銹鋼等管道。No step or pull PVC piping, plastic piping, hazardous chemical pipes, small stainless steel pipes, etc..(1000 RMB)
3．不可踩在通風過濾網上。Do not step on FFU. (1000 RMB)
1．移動架子的輪子和其他使用的輪子要用許可的膠帶纏好，以防止地面劃傷。Scaffold wheels or any other wheels shall be wrapped with approved tape to protect ground.(500 RMB)
2．人字梯的支腳也需要加保護套。Note booties on ladder feet. .(200 RMB each item每件)
3．包裹輪子的膠帶如果弄臟要及時更換。Noted new cleanroom taped to wheels if it was dirty. .(200 RMB each item每件)
4．輪子的膠帶如果破損、丟失要重新更換。Replaced a new cleanroom taped if it was lose or damaged. .(200 RMB each item每件)
5．梯子/移動平臺放置地面時,下面要鋪保護革或塑料墊。Must lay floor protection vinyl sheet?or plastic sheet below ladders or working platform.(200 RMB each item每件)
6．施工區域、材料、工具放置地面時，下面需要鋪保護革或塑料墊。Lay floor protection vinyl sheet or plastic sheet below materials.(200 RMB each item每件)
7．做好防護措施，防止油污弄臟潔凈室的地面。Avoid oil stains on the floor due to the dirty work at cleanroom.(200 RMB)
8．不可放置任何材料或工具靠近潔凈室的墻面，必須保持一米以上的間隔。Do not lay any materials or tools next to cleanroom wall; Away cleanroom wall at least 1 meter.(200-400 RMB)
9.使用工具或材料搬運時，該物品必須完全離開地面，不準在地上拖行。Moving tools or materials must be off ground. .(400 RMB each item每件)
